Product ID:METALCLAD CERAMALLOY CL PLUS BLUE BASE
MSDS Date:12/01/1991
FSC:8040
NIIN:00N033942
MSDS Number: BPTNJ

PALMER INTERNATIONAL INC

WORCESTER, PA 19490
US

Emergency Phone: 215-584-4241

Info Phone: 215-584-4241

Preparer: F. LAUMAN

Cage: 00933

PALMER INTERNATIONAL, INC.

WORCESTER, PA 19490 US

Telephone: 610-584-4241

Cage: 00933

<0.1

CAS: 25068-38-6

RTECS: KC2100000

Fraction By Weight: 20-25%

EPOXY PHENOL NOVOLAC RESIN; (EPOXY PHENOL NOVOLAC)

CAS: 28064-14-4

Fraction By Weight: <5%

ZIRCONIUM OXIDE

CAS: 1314-23-4

RTECS: ZH8800000

Fraction By Weight: 70-75%

OSHA PEL 5 MG/M3;10 STEL (ZR)

ACGIH TLV: 5 MG/M3;10 STEL (ZR)

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:EYES: CAN CAUSE IRRITATION. SKIN:
PROLONGED OR REPEATED CONTACT CAN CAUSE MODERATE IRRITATION;
DERMATITIS. INHAL: NORMALLY NO PROBLEM UNLESS HEATED. INGEST:
SLIGHTLY TOXIC.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.

First Aid:EYES:FLUSH W/LGE AMTS OF WATER FOR AT LEAST 15 MINS LIFTING
EYELIDS OCCASNLY. GET MD PROMPTLY. SKIN:WASH THORO W/SOAP & WATER.
REMOVE CONTAMD CLTHG PROMPTLY; WASH CLTHG BEFORE REUSE. INGEST:DO
NOT IND UCE VOM! KEEP PERS WARM, QUIET & GET MD. ASPIR OF MATL INTO
LUNGS DUE TO VOM CAN CAUSE CHEM PNEUMIT WHICH CAN BE FATAL.
INHAL:MOVE AFFECTED PERS TO FRESH AIR. IF BRTHG IS DFCLT, ADMIN
O*2. (SUPP DATA)

Flash Point:>400F,>204C
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, FOAM & WATER FOG. USE
WATER FOR COOLING MATERIAL STORED IN VICINITY OF FIRE.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE.

Spill Release Procedures:SMALL/LARGE SPILL:SCRAPE UP/SOAK UP
W/ABSORBENT MATERIAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:NONE.
Other Precautions:NONE.

Respiratory Protection:IF TLV OF PROD IS EXCEEDED, A NIOSH/MSHA APPRVD
AIR SUPPLY RESP IS ADVISED IN ABSENCE OF PROPER ENVIRON CONTROL.
OSHA REGS ALSO PERMIT OTHER NIOSH/MSHA APPRVD RESPS UNDER SPECIFIED
CNDTNS. (SEE YOUR S FTY EQUIP SUPPLIER). (SUPP DATA)
Ventilation:PROVIDE SUFFICIENT MECHANICAL (GENERAL &/OR LOCAL EXHAUST)
VENTILATION TO MAINTAIN EXPOSURE BELOW TLV.
Protective Gloves:RESISTANT GLOVES (SUCH AS NITRILE RUB).
Eye Protection:CHEMICAL WORKERS GOGGLES .
Other Protective Equipment:EYE WASH & SAFETY SHOWER.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
FIRST AID PROC:IF BREATHING HAS STOPPED, GIVE ARTIFICIAL RESPIRATION.
KEEP PERSON WARM, QUIET & GET MD. RESP PROT:ENGINEERING OR
ADMINISTRATIVE CONTROLS SHOULD BE IMPLEMENTED TO REDUCE EXPOSURE.

HCC:N1
Boiling Pt:B.P. Text:392F,200C
Vapor Density:HVR/AIR
Spec Gravity:2.82
Evaporation Rate & Reference:NON VOLATILE
Appearance and Odor:BLUE PASTE.
Percent Volatiles by Volume:0%

Stability Indicator/Materials to Avoid:YES
AVOID CONTACT W/STRONG OXIDIZERS, ACIDS, AMINES & BASES.
Stability Condition to Avoid:KEEP AWAY FROM HEAT & OPEN FLAME.
Hazardous Decomposition Products:MAY FORM CO & CO*2, VARIOUS
HYDROCARBONS, ETC.

Waste Disposal Methods:SMALL/LARGE SPILL:INCINERATE OR LANDFILL IN
ACCORDANCE W/ALL FEDERAL, STATE & LOCAL REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.